Product ID:DECORATIVE COATING, DV48200, UCD 4820V
MSDS Date:01/11/1995
FSC:8010
NIIN:00N060946
MSDS Number: BXXDL

MORTON INTERNATIONAL

2701 E 170TH ST
LANSING, IL 60438
US

Emergency Phone: 800-424-9300(CHEMTREC)

Info Phone: 708-474-7000

Cage: DO471

MORTON INTERNATIONAL; SPECIALTY CHEM GRP

UNKNOW CHICAGO, IL 60606-1292

Telephone: 815-338-1800

Cage: DO471

ACETIC ACID, 2-METHOXY-1-METHYLETHYL ESTER;

CAS: 108-65-6

RTECS: AI8295000

Fraction By Weight: 54 +/-3%

OSHA PEL N/K

ACGIH TLV: N/K

COPPER (SARA 313) (CERCLA)

CAS: 7440-50-8

RTECS: GL5325000

Fraction By Weight: 4.36%

OSHA PEL 0.1MG/M3 FUME;1 DUST

ACGIH TLV: 0.2 MG/M3 FUME

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE:CAN CAUSE IRRIT FROM VAPS
&/OR LIQ CONT. INHAL:EXCESSIVE INHAL OF VAPS CAN CAUSE IRRIT OF
RESP SYS. SKIN:RPTD/PRLNG CONT CAUSES IRRIT. RPTD/PRLNG CONT MAY
CAUSE DEFAT & DERM. INGEST:CAN CAUS E GI IRRIT, NAUS, VOMIT &
DIARR. ASPIR OF MATL INTO LUNGS MAY CAUSE CHEM PNEUM WHICH CAN BE
FATAL. CHRONIC:INHAL:RPTS HAVE ASSOC RPTD & PRLNG OCCUP OVEREXP TO
SOLVS W/PERM BRAIN & NERV SYS DMG. ING 2: EYE CONT W/COPPER DUST
MAY CAUSE REDNESS & PAIN. SKIN CONT MAY RSLT IN ALLERGIC RXN,
IRRIT/KERATINIZATION. INHAL OF DUST MAY IRRIT UPPER RESP SYS.
INGEST CAN CAUSE NAUS, VOMIT. PERSONS W/WILSON'S DISE ASE MAY
ABSORB & RETAIN(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: UNUSUALLY HIGH LEVELS OF COPPER & MAY
BE SERIOUSLY AFFECTED BY EXPOSURE TO COPPER.
Medical Cond Aggravated by Exposure:PERSONS W/PRE-EXISTING SKIN OR
RESPIRATORY DISORDERS MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF THE
PRODUCT.

First Aid:EYES:FLUSH IMMEDIATELY W/LARGE AMOUNTS OF WATER FOR AT LEAST
15 MINUTES. OBTAIN IMMEDIATE MEDICAL ATTENTION. SKIN:WASH THORO
W/SOAP & WATER. REMOVE CONTAMINATED CLOTHING. CONSULT MD IF IRRIT
PERSISTS. INGEST:THORO WASH MOUTH W/WATER. GIVE 2 GLASSES OF WATER
IF CONSCIOUS. DO NOT INDUCE VOMIT. INHAL:REMOVE TO FRESH AIR. IF
BRTHG HAS STOPPED, GIVE ARTF RESP. OBTAIN IMMED MED ATTN.

Flash Point Method:TCC
Flash Point:116F,47C
Lower Limits:SEE ING 1
Extinguishing Media:USE CARBON DIOXIDE OR DRY CHEMICAL EXTINGUISHERS
FOR SMALL FIRES. USE FOAM FOR LARGE FIRES.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . COOL CLOSED CONTAINERS W/WATER SPRAY.
Unusual Fire/Explosion Hazard:CLSD CNTNRS MAY BUILD EXPLO PRESS FROM
HEAT. VAPS ARE HVR/AIR & MAY TRAVEL CONSIDERABLE DISTS TO SOURCE OF
IGNIT SUCH AS SPK, PILOT LIGHT, CIGARETTE/UNPROT ELEC DEVICE. NOT
SENSITIVE TO EXPLO UPON MEC H IMPACT. VAPS MAY TRAVEL ALONG
GROUND/BE MOVED BY VENT & IGNITED BY HEAT, PILOT LIGHTS, FLAMES &
IGNIT SOURCES (SUPDAT)

Spill Release Procedures:SM SPILLS:STOP DISCHARGE & CONTAIN SPILL.
RECOVER W/EXPLO PROOF PUMPING EQUIP, COMMERCIAL SORBENTS,
VERMICULITE/OTHER INERT ABSORB MATLS. PLACE IN APPROP CNTNR(S) FOR
FURTHER HNDLG. LG SPILLS:STOP DIS CHARGE, CONTAIN SPILL/CONTAM MATL
USING DIKE, BARRIER/OTHER MEANS. RECOVER W/VACUUM TRUCK,
SORBENTS/OTHER INERT ABSORB MATLS. PLACE IN APPROP CNTNR(S) FOR
FURTHER HNDLG. HAZS TO BE (SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & FLAME.
USE W/ADEQUATE VENTILATION. KEEP CONTAINERS CLOSED.
Other Precautions:GROUND & BOND EQUIPMENT AGAINST STATIC BUILDUP WHEN
POURING, DISPENSING & MIXING. AVOID CONTACT W/SKIN OR EYES. AVOID
PROLONGED OR REPEATED BREATHING OF VAPORS. DO NOT TAKE INTERNALLY.

Respiratory Protection:APPLICATIONS USING ISOCYANATE CATALYST REQ USE
OF NIOSH/MSHA APPRVD SUPPLIED AIR RESPS/HOODS UNLESS EXPOS ARE
KNOWN TO BE LOWER THAN ALLOWABLE EXPOS LIMS. NONE NEEDED IF ADEQ
VENT IS PROVIDED OTHERWIS E NIOSH/MSHA APPRVD W/ORG VAP CARTRIDGES
IS REC W/IN RESP TYPE LIMITATIONS. RESP USE MUST COMPLY W/OSHA
1910.134 REGS. SINCE CONTAM LEVELS WILL VARY(OTHER INFO)
Ventilation:AIR POLLUTION CONTROLS MAY BE REQD. CHECK LOC & STATE REGS.
PROVIDE SUFFICIENT MECH (GEN &/OR LOC EXHST) VENT TO MAINTAIN
EXPOSURE BELOW PEL TLV(S).
Protective Gloves:CHEMICAL RESISTANT GLOVES.
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS .
Other Protective Equipment:TO PREVENT RPTD/PRLNG SKIN CONTACT WEAR PROT
WORK CLOTHES. HAVE EYE WASHES & SAFETY SHOWERS READILY ACCESSIBLE.
Work Hygienic Practices:CONTACT LENSES SHOULD NOT BE WORN. WASH
CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
EXPLO HAZ: AT LOCATIONS DIST FROM MATL. CONT W/HEAT MAY RSLT IN PRESS
RELS FROM CLSD CNTNRS. AVOID STATIC CHARGE, GROUND & BOND EQUIP
AGAINST STATIC BUILDUP WHEN POURING, DISPENSING & MIXING. HIGH TEM
PERATURES MAY CAUSE FIRE &/OR EXPLOSION. SPILL PROC:
AVOIDED:COMBUST LIQ-AVOID SOURCES OF IGNIT. DO NOT (OTHER INFO)

Boiling Pt:B.P. Text:284F,140C
Vapor Pres:SEE ING 1
Vapor Density:HVR/AIR
Spec Gravity:1.09
VOC Grams/Liter:4.96
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:PHTHALO BLUE G.S.
Percent Volatiles by Volume:62+/-3

Stability Indicator/Materials to Avoid:YES
OXIDIZERS.
Stability Condition to Avoid:HIGH TEMPERATURE, IGNITION SOURCES.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE.

Waste Disposal Methods:(1)RECYCLE, IF FEASIBLE. (2)INCIN AT AUTH
FACILITY. (3)TREATMENT AT INDUS/LIQ WASTE TREATMENT FACILITY.
(4)LANDFILL AFTER SOLIDIFICATION IN FACILITY AUTH TO RECEIVE WASTE
I/A/W FED, STATE & LOC REGS. NOTE:THIS MATL IF BEING DISCARDED
WOULD BE CLASSIFIED HAZ IGNITABLE WASTE & SHOULD BE DISPOSED I/A/W
LOCAL, STATE & FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.